| | 
Yamaha Raptor 700R Repair Manual 2006-2009 |
 The 2006-2009 Yamaha Raptor 700R repair manual by Clymer, covers models indicated and includes information specific to Yamaha YFM700R, YFM70R, and YFM70RSE All-Terrain Vehicles.
Book Excerpt: 2006-2009 Yamaha Raptor 700R Repair Manual
FRONT SUSPENSION AND STEERING
This chapter provides service procedures for the front suspension and steering components. Refer to the Table 1 and Table 2 at the end of this chapter for specifications.
HANDLEBAR | ADJUSTMENT
- Withdraw the fuel tank vent hose (A, Figure 1) from the handlebar cover.
- Push up and remove the handlebar cover (B, Figure 1).
- Loosen the rear (A, Figure 2), and then the front (B) handlebar holder bolts.
- Tilt the handlebar to the desired position.
- Tighten the front (B, Figure 2), and then the rear (A) handlebar holder bolts to 23 N.m (17 ft. lb.).
REMOVAL AND INSTALLATION
- Withdraw the fuel tank vent hose (A, Figure 1) from the handlebar cover.
- Push up and remove the handlebar cover (B, Figure 1).
- Remove cable and hose bands.
- Remove the front master cylinder as described in Chapter Fourteen.
- Remove the throttle housing clamp screws (A, Figure 3), clamp (B) and throttle housing (C). Place the throttle housing out of the way.
WHEELS, TIRES AND DRIVE CHAIN
DRIVE CHAIN
Refer to Chapter Three for drive chain cleaning, lubrication, adjustment and measurement. Refer to Table 3 in this chapter for drive chain specifications.
When checking the condition of the chain, also check the condition of the sprockets (Chapter Three).
If either the chain or sprockets are worn, replace all drive components. Using new sprockets with a worn chain, or a new chain on worn sprockets will shorten the life of the new part.
The vehicle is originally equipped with an endless O-ring type chain. This type of chain is recommended because it is internally lubricated and requires minimal maintenance.
The chain is permanently assembled, which increases reliability. However, to remove the chain, the swing arm must be partially disassembled so the chain can pass by the swing arm pivot.
TABLE of CONTENTS:
- General Information
- Troubleshooting
- Lubrication, Maintenance and Tune-up
- Engine
- Clutch and External Gearshift Linkage
- Transmission and Internal Shift Mechanism
- Fuel and Emission Systems
- Exhaust System
- Electrical System
- Wheels, Tires and Drivetrain
- Front Suspension and Steering
- Rear Suspension
- Brakes
- Body and Frame
- Wiring Diagrams
Subject: 2006, 2007, 2008, 2009 Yamaha Raptor 700R service, maintenance, repair. ISBN-10: 1599692961 | ISBN-13: 9781599692968 | Clymer M290
|
PRODUCT SPECIFICATIONS:- Publisher: Clymer Manuals
- Pages: 312 - Hundreds of b&w photos and illustrations
- Binding: Paperback - 7 x 10 inches
- ISBN: 978-1-59969-296-8
|
