| | 
OMC Cobra Stern Drive Shop Manual 1994-2000
 This repair and service manual covers OMC Cobra Stern Drive engines, 1994-2000 including, 3.0GL, 3.0GS, 4.3GL, 4.3GS, 4.3GI, 5.0GL, 5.0GI, 5.0FL, 5.0FI, 5.0FSI, 5.7GL, 5.7GS, 5.7GI, 5.8FL, 5.8FI, 5.8FSI, 7.4GL, 7.4GI, 7.4GSI, 8.2GL, 8.2GI, and 8.2GSI.
Table of Contents
QUICK REFERENCE DATA
CHAPTER ONE: GENERAL INFORMATION
Manual organization | Warnings, cautions and notes | Safety | Model identification | Engine operation | Fasteners | Shop supplies | Galvanic corrosion | Propellers | Basic tools | Special tools | Precision measuring tools | Electrical system fundamentals | Basic mechanical skills | Specifications
CHAPTER TWO: TROUBLESHOOTING
Preliminary inspection | Electric starting system | Charging system | Ignition system | Basic fuel system troubleshooting | Electronic fuel injection (EFI) system | Diagnostic trouble codes | Power steering system | Power trim system | Cooling system troubleshooting | Warning system | Engine | Drive system | Specifications
CHAPTER THREE: LUBRICATION, MAINTENANCE and TUNE-UP
Before each use | After each use | Lubrication | Fuel system maintenance | Engine coolant | Tune-up | Submersion | Specifications
CHAPTER FOUR: LAY-UP, WINTERIZING and FITTING OUT
Lay-up | Winterizing | Fitting out
CHAPTER FIVE: ADJUSTMENTS
Carburetor adjustment | Ignition timing adjustment | Shift cable adjustment | Throttle cable adjustment | Trim position sender and trim limit control module adjustment | Specifications
CHAPTER SIX: ENGINE
Engine operation | Special tools | Replacement parts | Special service precautions | Engine removal | Engine installation | Engine alignment | Rocker arm cover | Valve adjustment | Placing the No. 1 piston at TDC (firing position) | Lifter cover | Measuring camshaft lobe lift | Cylinder head | Valves and valve seats | Rocker arm and pushrod | Flywheel housing, drive coupler and flywheel | Oil pan | Oil pump | Harmonic balancer | Timing gear or chain cover and oil seal | Timing chain and sprockets | Balance shaft | Camshaft and lifters | Piston and connecting rod | Crankshaft and rear main seal | Break-in procedure | Specifications
CHAPTER SEVEN: FUEL SYSTEM
Servicing the fuel system | Mechanical low-pressure fuel pump | Low-pressure electric fuel pump | Flame arrestor and cover | Carburetor | Electronic fuel injection (EFI) | Throttle body | Intake plenum, fuel rail and injectors | Fuel pressure regulator | High-pressure electric fuel pump | Fuel reservoir | Intake manifold | Specifications
CHAPTER EIGHT: COOLING and EXHAUST SYSTEMS
Thermostat | Hose replacement | Recirculation pump replacement | Seawater pump | Oil and power steering fluid coolers (replacement) | Exhaust elbow | Exhaust bellows, exhaust tube and flapper valve | Exhaust manifold | Specifications
CHAPTER NINE: ELECTRICAL SYSTEM
Battery | Alternator | Starter and starter solenoid | Ignition system | Starter slave solenoid | Starter relay | Fuel pump relay | Electronic fuel injection (EFI) system relay | Oil pressure sender | Oil pressure switch | Coolant temperature sender | Coolant temperature sensor | Engine overheat switch | Manifold air pressure sensor | Intake air temperature (IAT) sensor | Throttle position sensor (TPS) | Idle air control motor (IAC) | Idle speed control solenoid (ISC) | Knock sensor (KS) | Knock sensor module | Knock sensor amplifier | Engine control unit (ECU) | Engine control assembly (ECA) | Specifications
CHAPTER TEN: DRIVE UNIT
Drive unit identification | Drive unit operation | Drive unit gear ratio | High altitude operation | Outdrive service precautions | Sacrificial anodes | Shifting and propeller rotation | Propeller | Drive unit | Universal joint service | Shift housing service | Lower gearcase | Drive unit pressure and vacuum tests | Specifications
CHAPTER ELEVEN: TRANSOM BRACKET
Pivot housing | Bellows and water hose | Gimbal bearing and seal | Gimbal ring | Inner transom plate and bracket housing | Specifications
CHAPTER TWELVE: POWER TRIM SYSTEM
Electrical trim system components | Hydraulic trim system components | Trim cylinder and hoses | Trim position sender | Filling and bleeding the trim system | Specifications
CHAPTER THIRTEEN: STEERING SYSTEM
Safety precautions | Mechanical (manual) steering system | Power steering system | Specifications
WIRING DIAGRAMS
Clymer marine repair manuals can save you money on maintenance and repair bills. Step-by-step procedures and detailed illustrations guide you through every job, from routine maintenance and troubleshooting, to complete teardown & rebuild.
|
 PRODUCT DETAILS:- Publisher: Clymer Manuals — 2007
- Author: Jay Bogart, Michael Morlan, Ed Scott, Ron Wright, et al
- Binding: Paperback — 8¼ x 10¾ x 1 inches
- Pages: 562 — Hundreds of b&w photos and illustrations
- ISBN: 1599691078
OMC Cobra Stern Drive Shop Manual 1994-2000 |
|