The 3-volume 1989-1991 Audi 100, 200 official factory repair manual contains comprehensive service and repair information for 1989, 1990, 1991 Audi models sold in the USA and Canada, including:
Book Excerpt: 1989-1991 Audi 100, 200 Official Factory Repair Manual FUEL SUPPLY
FUEL PUMP, CHECKING
TURBOCHARGER
Subject: 1989, 1990, 1991 Audi 100, 200 factory service, maintenance, repair. ISBN-10: 0-8376-0372-2 | ISBN-13: 9780837603728 | Bentley A191
- Audi 100
- Audi 100 Quattro
- Audi 200
- Audi 200 Turbo
- Audi 200 Quattro Turbo
- Audi 200 Quattro 20V Turbo
- 2.2L 5-cylinder (code MC)
- 2.2L 5-cylinder 20-V (code 3B)
- 2.3L 5-cylinder (code NF)
- 3-speed automatic (codes REE, REH)
- 4-speed automatic (code AEK)
- 5-speed manual 2WD (codes AMK, APV)
- 5-speed manual AWD ( codes ADZ, AML, AOA, AUM, AXM)
- Rear final drive - manual (codes AAT, AET)
Book Excerpt: 1989-1991 Audi 100, 200 Official Factory Repair Manual FUEL SUPPLY
FUEL GAUGE SENDING UNIT | REMOVING
- Remove luggage compartment cover
- Remove sending unit access cover
- Remove harness connector
- Pull off supply line A, return line B and vent hose C (see illustration)
- Loosen retaining sleeve and pull out fuel gauge sending unit (using tool 3087)
- Pull off fuel hoses inside of sender housing
- Detach electrical connections
- Remove gravity valve
FUEL PUMP, CHECKING
REQUIREMENTS:
- battery must be fully charged (12 volts minimum)
- fuse #13 OK
- fuel filter must be clean and properly installed
- remove fuel pump relay from fuse relay panel (relay location 10)
- connect remote control VW 1348-3A to terminal 52 using adaptor VW 1348/3-2
TURBOCHARGER
REMOVING
- Disconnect battery ground cable
- Remove intake air boot between intercooler and throttle valve body (see arrows)
- Remove air intake boot (right arrows)
- Remove vacuum hose between turbocharger and air intake duct (left arrow)
- Unclip air filter cover (see arrows)
- Remove oxygen sensor and CO measuring tube (see arrows)
Subject: 1989, 1990, 1991 Audi 100, 200 factory service, maintenance, repair. ISBN-10: 0-8376-0372-2 | ISBN-13: 9780837603728 | Bentley A191
TABLE of CONTENTS:
- OWNER INFORMATION: Vehicle Care | Do-it-yourself Service | Gas Station Information | Technical Data | Maintenance/Lubrication Schedule
- GENERAL ENGINE: General | Engine | Engine-Assembly | Crankshaft/Crankcase | Cylinder Head/Valve Drive | Lubrication System | Cooling System
- FUEL SUPPLY, TURBOCHARGER, FUEL INJECTION: Fuel Supply | Turbocharger | Fuel Injection AFC System (20-valve turbo) | Continuous Injection System | Diagnosis, Fault Memory
- EXHAUST, ENGINE ELECTRICAL, IGNITION: Exhaust System/Emission Controls | Electrical-Battery, Alternator, Starter, Cruise Control | Ignition System
- MANUAL TRANSMISSION (100 Models): Clutch | Controls, Assembly | Case, Gears, Shafts | Differential
- MANUAL TRANSMISSION (200 Models, FWD): Clutch | Controls, Assembly | Case, Gears, Shafts | Differential
- MANUAL TRANSMISSION (200 Models, Quattro): Clutch | Controls, Assembly | Case, Gears, Shafts | Differential
- AUTOMATIC TRANSMISSION: Diagnosis, Fault Memory (097 4-speed) | Torque Converter | Controls, Assembly | Case, Gears, Shafts | Differential | Suspension | Front Suspension-Shafts and Axle | Rear Suspension-Shafts and Axle | Wheels, Tires, Wheel Alignment
- BRAKES, STEERING: ABS-Anti-Lock Brake System | Steering | Brake-Mechanical Components | Brake-Hydraulic Components, Regulator, Booster
- BODY, EXTERIOR: Body | Hoods/Lids | Doors-Front | Doors-Rear | Sunroof | Bumpers | Glass, Window Regulators | Body Accessories-Exterior
- BODY, INTERIOR: Body Accessories-Interior, Airbag | Trim-Interior Seats | Body-Seat Upholstery
- CLIMATE CONTROL: Diagnosis, Fault Memory | Air Conditioner
- ELECTRICAL: Electrical System-Instruments | Radio, Telephone, Board Computer | Windshield Wiper and Washer | Exterior Lights | Interior Lights | Wiring
- WIRING DIAGRAMS: General Information | Wiring diagrams
