Buick Century, Chevy Celebrity, Olds Ciera, Cutlass, Cruiser, Pontiac 6000 Repair Manual 1982-1996

SKU: CH28360-996

Buick Century, Chevy Celebrity, Olds Ciera, Cutlass, Cruiser, Pontiac 6000 Repair Manual 1982-1996

SKU: CH28360-996
MSRP: $49.95
Only $39.89
free shipping (US48)

out of stock | item #: CH28360-996

Contact us for availability

Out of stock

Why Buy From Us?

  • Free Shipping
  • Veteran Owned
  • Secure Shopping
  • Satisfaction Guaranteed

Buick Century, Chevy Celebrity, Olds Ciera, Cutlass, Cruiser, Pontiac 6000 Repair Manual 1982-1996

MSRP: $49.95
Only $39.89
free shipping (US48)

out of stock

The 1982-1996 Buick Century, Chevrolet Celebrity, Oldsmobile Ciera, Cutlass, Cruiser, Pontiac 6000 Repair Manual by Chilton, covers car models mentioned. Complete maintenance, service and repair instructions, accompanied by hundreds of pictures, show you how to take care of your car properly, while saving money.
Book Excerpt: 1982-1996 Buick Century, Chevrolet Celebrity, Oldsmobile Ciera, Cutlass, Cruiser, Pontiac 6000 Repair Manual ENGINE AND ENGINE OVERHAUL
VALVE/ROCKER COVER(S) | REMOVAL AND INSTALLATION
(See Figure 19) 2.2L ENGINE
  1. Clean all the dirt from around the mating area of the valve cover.
  2. Disconnect the PCV valve from the valve cover.
  3. Remove the valve cover bolts.
  4. Remove the valve cover by tapping it with a rubber mallet. This must be done to break the seal. DON'T attempt to pry the cover off, as it is easily damaged.
  5. Clean the sealing surface on the head and the valve cover with a degreaser.
  6. TO INSTALL
  7. Attach a new gasket in the mating area of the head.
  8. Install the valve cover to the head; tighten the cover bolts to 89 inch lbs. (10Nm).
  9. Install the PCV valve.
  10. Add engine oil if needed. Start the engine and check for leaks.

2.5L ENGINE (See Figure 20)
  1. Clean all the dirt from around the mating area of the valve cover.
  2. Remove the air cleaner assembly, being sure to tag all disconnected hoses for reassembly purposes.
  3. Remove the PCV valve and hose from the valve cover grommet.
  4. Remove the spark plug wires from the spark plugs and the location clips. Be sure to tag the wires so that they may be attached properly.
  5. Remove the crankcase vent tube from the cover.
  6. Remove the EGR valve.
  7. Remove the cover retaining bolts, and then the valve cover by tapping it with a rubber mallet. This must be done to break the seal. DON'T attempt to pry the cover off, as it is easily damaged.
  8. Clean the mating surface on the head and valve cover assembly.
  9. TO INSTALL
  10. Install a new valve cover gasket on the cylinder head mating surface, and then the cover.
  11. Install the valve cover bolts; tighten to 80 inch lbs. (9 Nm).
  12. Install the EGR valve with a new gasket.
  13. Install the crankcase vent tube to the valve cover.
  14. Attach the spark plug wires to the spark plugs, and then attach the clip on the cover.
  15. Install the air cleaner assembly.
  16. Start the engine, check for leaks.

DRIVE TRAIN
REAR AXLE | 6000 STE AWD (See Figure 8)
  1. Raise and safely support the vehicle.
  2. Remove the tire and wheel assembly.
  3. Disconnect the parking brake cable end from the bracket.
  4. Remove the bolts securing the brake line and the Electronic Ride Control (ERC) sensor bracket to the control arm. Loosen the anti-lock brake sensor bolt and move the sensor out of the way.
  5. Insert a suitable tool through the caliper into the rotor to prevent the rotor from turning.
  6. Remove the shaft nut and washer using special tool J-34826. Discard the shaft nut.
  7. Remove the 2 brake caliper bolts and remove the caliper. Support the caliper using a length of wire.

Subject: 1982, 1983, 1984, 1985, 1986, 1987, 1988, 1989, 1990, 1991, 1992, 1993, 1994, 1995, 1996 Buick Century, Chevrolet Celebrity, Oldsmobile Ciera, Cutlass, Cruiser, Pontiac 6000 service, maintenance, repair. ISBN-10: 0801991080 | ISBN-13: 9780801991080 | Chilton 28360
TABLE of CONTENTS: Introduction: About this manual | Introduction | Vehicle identification numbers | Maintenance techniques, tools and working facilities | Buying parts | Jacking and towing | Anti-theft audio system | Booster battery (jump) starting | Conversion factors | Automotive chemicals and lubricants | Safety first! | Troubleshooting
  • Tune-up and routine maintenance
  • Engine and overhaul procedures
  • Cooling, heating and air-conditioning systems
  • Fuel and exhaust systems
  • Engine electrical systems
  • Emissions control systems
  • Transmission
  • Brakes
  • Suspension and steering systems
  • Body
  • Chassis electrical system
  • Wiring diagrams

Specifications

  • Publisher: Chilton Manuals
  • Pages: 298 - Hundreds of b&w photos and illustrations
  • Binding: Paperback - 8.25 x 10.75 inches
  • ISBN: 978-0-8019-9108-0
  • Years: 1982 - 1996